User manual GAF EVERGUARD WB181 BONDING ADHESIVE MATERIAL SAFETY DATASHEET UPDATED 07-2010

[. . . ] EverGuard® WB181 Bonding Adhesive Material Safety Data Sheet MSDS #2132 Updated: 7/2010 Your Best and Safest ChoiceTM. . . Quality You Can Trust Since 1886! GAF Materials Corporation Material Safety Data Sheet MSDS # 2132 MSDS Date: July 2010 _________________________________________________________________________ SECTION 1: PRODUCT AND COMPANY INFORMATION PRODUCT NAME: TRADE NAME: CHEMICAL NAME / SYNONYM: CHEMICAL FAMILY: MANUFACTURER: ADDRESS: 24-HOUR EMERGENCY PHONE (CHEMTREC): INFORMATION ONLY: PREPARED BY: APPROVED BY: EverGuard® WB181 Bonding Adhesive N/A Adhesive Mixture GAF Materials Corporation 1361 Alps Road, Wayne, NJ 07470 800 ­ 424 ­ 9300 800 ­ 766 ­ 3411 Corporate EHS Corporate EHS NFPA Hazard Rating Health Flammable Reactive Special Hazards OSHA HAZARDOUS: 1 0 0 Yes Health Flammable Reactive Personal Protection HMIS Hazard Rating 1 0 0 X No X SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS OCCUPATIONAL EXPOSURE LIMITS CHEMICAL NAME Acrylic Polymer(s) Individual Residual Monomers CAS # % (BY WT) 20 ­ 80 < 0. 1 OSHA NE NE ACGIH NE NE OTHER NE NE OCCUPATIONAL EXPOSURE LIMITS Page 1 of 7 GAF Materials Corporation CHEMICAL NAME Aqua Ammonia CAS # 1336-21-6 % (BY WT) <=0. 3 OSHA 50 ppm ACGIH MSDS # 2132 OTHER REL: 25 ppm 35 ppm ­ STEL NE 25 ppm 35 ppm ­ STEL 5 mg/m3 ­ resp. [. . . ] Stir well before use. OTHER PRECAUTIONS: SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION ENGINEERING CONTROLS / VENTILATION: Work should be done in an adequately ventilated area. Local exhaust ventilation is recommended when general ventilation is not sufficient to control airborne contamination. Use NIOSH approved respirator if there is potential to exceed exposure limit(s). RESPIRATORY PROTECTION: Page 3 of 7 GAF Materials Corporation EYE PROTECTION: SKIN PROTECTION: MSDS # 2132 Safety goggles or safety glasses with side shields. Use impermeable gloves (Neoprene) and protective clothing as necessary to prevent skin contact. Wash exposed skin prior to eating, drinking or smoking and at the end of each shift. Wash contaminated clothing prior to reuse. OTHER PROTECTIVE EQUIPMENT: WORK HYGIENIC PRACTICES: SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES APPEARANCE & ODOR: FLASH POINT: METHOD USED: EVAPORATION RATE: White milky liquid with a ammonia odor. Noncombustible No Data No Data LOWER EXPLOSIVE LIMIT: UPPER EXPLOSIVE LIMIT: BOILING POINT: No Data No Data 100 °C (212° F) water 0 °C (32° F) water 1. 1 (Water = 1) 20 ­ 80% water No Data pH (undiluted product): SOLUBILITY IN WATER: VAPOR DENSITY: VAPOR PRESSURE: 6. 5 - 11 Dilutable <1. 0 17 hPa at 20° C (68° F) No Data MELTING POINT: SPECIFIC GRAVITY: PERCENT VOLATILE: MOLECULAR WEIGHT: VOC WITH WATER (LBS/GAL): WITHOUT WATER (LBS/GAL): No Data SECTION 10: STABILITY AND REACTIVITY THERMAL STABILITY: CONDITIONS TO AVOID (STABILITY): INCOMPATIBILITY (MATERIAL TO AVOID): HAZARDOUS DECOMPOSITION OR BYPRODUCTS: HAZARDOUS POLYMERIZATION: STABLE X Freezing conditions. N/A UNSTABLE Thermal decomposition may yield acrylic monomers. Will not occur. Page 4 of 7 GAF Materials Corporation MSDS # 2132 _________________________________________________________________________________________ _ SECTION 11: TOXICOLOGICAL INFORMATION TOXICOLOGICAL INFORMATION: Acute Oral Toxicity Acute Dermal Toxicity Skin Irritation Eye Irritation LD50 rat > 5, 000mg/kg LD50 rat > 5, 000mg/kg Rabbit may cause transient irritation. Rabbit no eye irritation. SECTION 12: ECOLOGICAL INFORMATION ECOLOGICAL INFORMATION: No information available. _________________________________________________________________________________________ _ SECTION 13: DISPOSAL CONSIDERATIONS WASTE DISPOSAL METHOD: This product, as supplied, is not regulated as a hazardous waste by the U. S. Environmental Protection Agency (EPA) under Resource Conservation and Recovery Act (RCRA) regulations. None RCRA HAZARD CLASS: SECTION 14: TRANSPORTATION INFORMATION U. S. DOT TRANSPORTATION PROPER SHIPPING NAME: This product is not classified as a hazardous material for transport. [. . . ] We do not accept liability for any loss or damage that may occur from the use of this information. Nothing herein shall be construed as a recommendation for uses which infringe valid patents or as extending a license of valid patents. Page 7 of 7 [. . . ]