User manual GAF EVERGUARD LOW VOC TPO PRIMER MATERIAL SAFETY DATASHEET UPDATED 09-2009

[. . . ] EverGuard® Low VOC TPO Primer Material Safety Data Sheet MSDS #2123 Updated: 9/2009 Your Best and Safest ChoiceTM. . . Quality You Can Trust Since 1886! GAF Materials Corporation Material Safety Data Sheet MSDS # 2123 MSDS Date: September 2009 _________________________________________________________________________ SECTION 1: PRODUCT AND COMPANY INFORMATION PRODUCT NAME: TRADE NAME: CHEMICAL NAME / SYNONYM: CHEMICAL FAMILY: MANUFACTURER: ADDRESS: 24 HOUR EMERGENCY PHONE: (CHEMTREC) INFORMATION ONLY: PREPARED BY: APPROVED BY: EverGuard® Low VOC TPO Primer N/A N/A N/A GAF Materials Corporation 1361 Alps Road, Wayne, NJ 07470 800 ­ 424­9300 800 ­ 766 ­ 3411 Corporate EHS Corporate EHS NFPA Hazard Rating Health Flammable Reactive Special Hazards OSHA HAZARDOUS: 2 3 1 Yes X Health Flammable Reactive Personal Protection HMIS Hazard Rating 2 3 1 X No SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS OCCUPATIONAL EXPOSURE LIMITS CHEMICAL NAME Parachlorobenzotrifluoride CAS # 98-56-6 % (BY WT) 65 ­ 75 OSHA NE ACGIH NE OTHER NE Page 1 of 7 GAF Materials Corporation MSDS # 2123 OCCUPATIONAL EXPOSURE LIMITS CHEMICAL NAME Toluene CAS # 108-88-3 % (BY WT) 15 ­ 25 OSHA 200 ppm 300 ppm ­ ceiling ACGIH 20 ppm OTHER REL: 100 ppm 150 ppm ­ STEL NE = Not Established SECTION 3: HAZARDS IDENTIFICATION PRIMARY ROUTE OF EXPOSURE: SIGNS & SYMPTONS OF EXPOSURE Eyes: Skin: Ingestion: Inhalation: Can cause severe irritation, redness, tearing, blurred vision. Prolonged inhalation of vapors may cause irritation of the respiratory tract and central nervous system depression (narcosis) characterized by headache, dizziness, muscular weakness and fatigue. [. . . ] Shovel or scoop into a sealable container for disposal. SECTION 7: HANDLING AND STORAGE HANDLING AND STORAGE: Do not store or handle near an ignition source. Effectively ground the product transfer system to prevent fire or explosion from static discharge. None. OTHER PRECAUTIONS: Page 3 of 7 GAF Materials Corporation MSDS # 2123 SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION ENGINEERING CONTROLS / VENTILATION: General exhaust as needed to keep work environment below exposure limits if engineering or administrative controls are not adequate. For large spills or entry into enclosed small spaces with inadequate ventilation, a pressure demand, self-contained breathing apparatus is recommended. If engineering or administrative controls are not adequate to maintain work environment below solvent TLV recommended levels, an appropriate respirator should be used in conjunction with a respirator use and fit training program. To prevent repeated or prolonged skin contact, wear impervious clothing and boots if contact is likely. Cleanse skin thoroughly after contact, before work breaks and meals, and at the end of the work day. Product is readily removed from the skin with waterless hand cleaners followed by washing thoroughly with soap and water. Eye wash stations should be available where product may come in contact with the eyes. N/A RESPIRATORY PROTECTION: EYE PROTECTION: SKIN PROTECTION: OTHER PROTECTIVE EQUIPMENT: WORK HYGIENIC PRACTICES: EXPOSURE GUIDELINES: SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES APPEARANCE & ODOR: FLASH POINT: METHOD USED: EVAPORATION RATE: pH (undiluted product): SOLUBILITY IN WATER: VAPOR DENSITY: VAPOR PRESSURE: VOC WITH WATER (g/L): Translucent liquid with aromatic odor. 45°F No data No data No data Insoluble >1 22 mm Hg @ 68°F 240 grams/liter LOWER EXPLOSIVE LIMIT: UPPER EXPLOSIVE LIMIT: BOILING POINT: MELTING POINT: SPECIFIC GRAVITY: PERCENT VOLATILE: MOLECULAR WEIGHT: WITHOUT WATER (g/L): 1. 2% 7. 0% 111°C No data 1. 15 ­ 1. 25 90% No data No data Page 4 of 7 GAF Materials Corporation MSDS # 2123 SECTION 10: STABILITY AND REACTIVITY THERMAL STABILITY: CONDITIONS TO AVOID (STABILITY): INCOMPATIBILITY (MATERIAL TO AVOID): HAZARDOUS DECOMPOSITION OR BYPRODUCTS: HAZARDOUS POLYMERIZATION: STABLE X UNSTABLE Avoid flames, sparks, or other sources of ignition. Avoid contact with acids, alkaline and strong oxidizing agents. Carbon dioxide, carbon monoxide, fluorine gas, chlorine gas, acrid smoke and irritating fumes. Will not occur. _________________________________________________________________________________________ SECTION 11: TOXICOLOGICAL INFORMATION TOXICOLOGICAL INFORMATION: No information available SECTION 12: ECOLOGICAL INFORMATION ECOLOGICAL INFORMATION: No information available. _________________________________________________________________________________________ SECTION 13: DISPOSAL CONSIDERATIONS WASTE DISPOSAL METHOD: This product, as supplied, is regulated as a hazardous waste by the U. S. Environmental Protection Agency (EPA) under Resource Conservation and Recovery Act (RCRA) regulations. If discarded in its purchased form, this product is a RCRA hazardous waste. It is the responsibility of the product user to determine at the time of disposal, whether a material containing the product or residue of the product remains classified a hazardous waste as per 40 CFR 261, Subpart C. [. . . ] It is the user's responsibility to satisfy himself as to the suitability and completeness of such information for his particular use. We do not accept liability for any loss or damage that may occur from the use of this information. Nothing herein shall be construed as a recommendation for uses which infringe valid patents or as extending a license of valid patents. Page 7 of 7 [. . . ]